Analysis of the Use of Palm Shells as a Substitute for Fine Aggregate on the Water Absorption of Concrete
DOI:
https://doi.org/10.32832/astonjadro.v14i4.19091Keywords:
water absorption, concrete, curing, palm oil, shell.Abstract
Concrete, as one of the main elements in construction, has received special attention and is commonly used in infrastructure development in various countries in the world. High-quality concrete is increasingly needed along with the increasing need for infrastructure, such as towers, high-rise buildings, and long-span bridges. This type of concrete is made with a low amount of FAS; FAS or water-to-cementitious ratio is the ratio of the total weight of water to the total weight of cement in the concrete mixture. The purpose of this study is to analyze the water absorption of concrete using palm shells as a substitute for fine aggregate using an experimental method by curing. From the results of testing palm shells such as the water absorption value which is directly proportional to the increasing percentage of CKS use as a substitute for fine aggregate, it show that the use of CKS as a substitute for fine aggregate in normal concrete increases the water absorption of concrete, the higher the percentage of palm shell substitution, the higher the percentage of absorption value obtained.
References
Boateng, E., Kankam, C. K., Danso, A. K., Ayarkwa, J., & Acheampong, A. (2023). Assessing Compressive Strength of Concrete with Waste Automobile Tire and Palm Kernel shells as Aggregates. In Journal of Engineering Research and Reports (Vol. 24, Issue 6). Hal. 8-9
Wasiu, John & Osegbowa, Douglas. (2022). Assessment of Palm Kernel Shell Powder Strengthened with Renolith as Partial Replacement for Cement. UNIOSUN Journal of Engineering and Environmental Sciences. 4. 10.36108/ujees/2202.40.0290. hal.6-7
Purwanti, Heny & Artiningsih, Titik. (2019). PALM KERNEL SHELL AS AN ALTERNATIVE AGGREGATE ON HIGH PERFORMANCE CONCRETE CONCRETE. Majalah Iptek Politeknik Negeri Medan Polimedia. Vol. 25 No. 3 (2022): Edisi Agustus. Hal. 8
R S Ramadhani dan Y Sitanggang. (2023). Pengaruh Penggunaan Abu Cangkang Sawit Terhadap Kuat Tekan, Kuat Lentur Dan Absorpsi Pada Beton. Journal of Science Innovare. 1. 68-75. 10.33751/jsi.v1i02.1004. Hal. 15
Muhammad Reja Palepy. (20210). Pengaruh Penambahan Limbah Abu Cangkang KelapaSawit Terhadap Kuat Tarik pada Beton dengan Bahan Tambahan Superplasticizer. Jurnal Ilmiah Mahasiswa Teknik. Vol 1, No 2. Hal.8
Syarifudin, Achmad & Yunanda, Mega & Anjani, Cristina. (2021). Analisis Kuat Tekan Beton K 225 Menggunakan Limbah Cangkang Kelapa Sawit Sebagai Pengganti Agregat KASAR. Jurnal Teknik Sipil. 10. 60-68. 10. Hal.67-68. Hal.13-14
Simanjuntak, J Saragih, T Lumbangaol, P Panjaitan, & Sintong. (2020). Beton Bermutu Dan Ramah Lingkungan Dengan Memanfaatkan Limbah Abu Cangkang Sawit. Jurnal Darma Agung. 28. 387. 10. Hal.13-14
HC Gunawan, C Mungok, Chrisna D, Y Lestyowati (2018) Pemanfaatan Abu Boiler Cangkang Kelapa Sawit Sebagai Bahan Tambah Pada Campuran Beton. Jurnal Mahasiswa Teknik Sipil Universitas Tanjungpura. Vol 5, No 2. Hal.7-8
Serwinda, A Hidayat, P Lumba (2013) Pengaruh Penambahan Cangkang Sawit Terhadap Kuat Tekan Beton F'c 25 Mpa. Jurnal Mahasiswa Teknik UPP, vol. 1, no. 1, Hal.7-8
Kristianto, C DMungok dan C P Handalan (2016) Pengaruh Penggunaan Cangkang Kelapa Sawit sebagai Bahan Tambah terhadap Mutu Beton. Jurnal Mahasiswa Teknik Sipil Universitas Tanjungpura, vol. 3, no. 3. Hal.8-9
Shalahuddin, Muhammad, dan A Azhari (2017) Analisa Karakteristik Beton Non Struktural Menggunakan Cangkang Sawit Sebagai Agregat Kasar. Poli-Teknologi, vol. 16, no. 1, Hal.6
Rahardja, VN. Surbakti, A L Siregar (2022) Empowering Abu Cangkang Kelapa Sawit Terhadap Kualitas Bata Beton Ringan (Light-weight Concrete). Jurnal Teknologi Universitas Muhammadiyah Jakarta, vol. 14, no. 1. Hal.7
Rahman, Fauzi, and Fathurrahman Fathurrahman (2017) Pemanfaatan Hasil Pembakaran Limbah Cangkang Kelapa Sawit sebagai Bahan Pengganti Pasir pada Pembuatan Beton Normal. Media Ilmiah Teknik Sipil, vol. 6, no. 1, Hal.10
H Kasuma, A Kurniawandy dan Ermiyati (2018) Pengaruh Penambahan Limbah Ekstraksi Buah Kelapa Sawit terhadap Pembuatan Beton. Jurnal Online Mahasiswa Fakultas Teknik Universitas Riau, vol. 5, no. 1, Hal.6-7
Subiyanto, Bambang, et al. "Komponen Kimia Cangkang Sawit (Elaeis Guineensis Jacq.) Dan Pengaruhnya Terhadap Sifat Beton Ringan Chemical Components of Oil Palm (Elaeis Guineensis Jacq.) Shell and Its Effect on Light Concrete Performance." Jurnal Ilmu dan Teknologi Kayu Tropis, vol. 5, no. 1, 2007, pp. 22-28. Hal. 27
Haspiadi, and Kurniawaty (2015) Pemanfaatan Limbah Padat Abu Cangkang dan Serat Kelapa Sawit dari Boiler untuk Pembuatan Bata Beton Ringan. Jurnal Riset Industri, vol. 9, no. 2, Hal.8
N. Ahmad, K. Muthusamy, R. Embong, L. Krishnaraj. 2024. Recycling of Oil Palm Shell as Aggregate in Concrete: A Review. University Malaysya Pahang Al-Sultan Abdullah. E-ISSN: 2785-8731. Hal. 9
MG Garcya, Z Djauhari, A Kurniawandy (2018) Pengaruh Penambahan Limbah Sisa Penyaringan Minyak Kelapa Sawit sebagai Bahan Tambah terhadap Kuat Tekan dan Kuat Lentur Beton. Jurnal Online Mahasiswa Fakultas Teknik Universitas Riau, vol. 5, no. 1, Hal.4-6
SU Azunna. (2019). Compressive strength of concrete with palm kernel shell as a partial replacement for coarse aggregate. SN Applied Sciences. 1. 10.Hal.9
Z Itam, S Beddu, NLKamal, MD Alam, dan UI Ayash. (2016). The Feasibility of Palm Kernel Shell as a Replacement for Coarse Aggregate in Lightweight Concrete. IOP Conference Series: Earth and Environmental Science. 32. 012040. 10, Hal.5
D.R Pangloly, Marthin, D.J.S., Dapas, (2018) Pengujian Kuat Tarik Belah Beton Geopolymer pada Perawatan Temperatur Ruangan”. Jurnal Sipil Statik 6, 743–750, Hal.7
Sutikno, (2003) Panduan Praktek Beton. Universitas Negeri Surabaya, Surabaya
Mc Cormac, Jack C (2001) Desain Beton Bertulang-Edisi Kelima-Jilid 1. Penerbit Erlangga:Jakarta. 14. Mc Cormac, Jack C 2004. Penerbit Airlangga, Jakarta
Tjokrodimuljo, K., 1992. Teknologi Beton, Jurusan Teknik Sipil, Fakultas Teknik, Universitas Gadjah Mada, Yogyakarta.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2025 ASTONJADRO
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Paper submitted to ASTONJADRO is the sole property of the Astonjadro Journal. Unless the author withdraws the paper because he does not want to be published in this journal. The publication rights are in the journal Astonjadro.ASTONJADRO
LICENSE
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Based on a work at http://ejournal.uika-bogor.ac.id/index.php/ASTONJADRO
